Article Sidebar
Published:
Oct 15, 2023Keywords:
Article Details
In accordance with the Copyright Act of 1976, which became effective January 1, 1978, the following statement signed by each author must accompany the manuscript submitted: "I, the undersigned author, transfer all copyright ownership of the manuscript referenced above to the Nigerian Journal of Technological Development, in the event the work is published. I warrant that the article is original, does not infringe upon any copyright or other proprietary right of any third party, is not under consideration by another journal, and has not been published previously. I have reviewed and approve the submitted version of the manuscript and agree to its publication in the Nigerian Journal of Technological Development." A copyright transfer form may be downloaded from the NJTD Website (http://njtd.com.ng/index.php/njtd). Author(s) will be consulted, whenever possible, regarding republication of material. All authors must have access to the data presented and the authors and sponsor (if applicable) must agree to share original data with the editor if requested.
Main Article Content
Capacities and irreversibility of the vapour compression refrigeration system’s components using aluminium oxide (Al2O3) based nanolubricants
Abstract
Hydrochlorofluorocarbon and chlorofluorocarbon refrigerants commonly used in vapour compression refrigeration system (VCRS) have been phased out due to their negative impact on the ecosystem. R134a and R600a refrigerants were considered as their replacement, but they possess low thermal properties, thereby affecting the performance of the VCRS. In this study, the effect of varying aluminium oxide (Al2O3) nanoparticle size (10 nm, 20 – 30 nm and 80nm) and volume concentration (1%, 3%, 5% 10% and 20%) on the capacity and exergy efficiency of each component of VCRS for the optimisation of the VCRS performance and reduction of energy consumption was analysed using R134a and R600a refrigerants. The nanolubricant were prepared using the two-step method. The VCRS showed no significant deterioration in the performance of its components as confirmed for over 24 hours when nanorefrigerant was used. The compressor capacity of nanorefrigerant was lower than that of pure refrigerants while the addition of nanoparticle enhanced the refrigeration effect. The exergy efficiency of the vapour compression system improved with the addition of nanoparticles into the system, the exergy destruction caused by friction in the compressor significantly reduced, thereby reducing the energy consumed by the system.
